Table Of Locations And Troubleshooting - TRAPP LT4217 Manual De Instrucciones

www.trapp.com.br

Table of Locations and Troubleshooting

Issue
The engine cannot be
started
It's difficult to start
Engine does not rotate
Probable cause
1. The engine is running out of fuel.
2. The choke was not used correctly.
3. The engine is drowned.
4. Defective spark plug.
5. Low or discharged battery.
6. Dirty air filter.
7. Dirty fuel filter.
8. Water in fuel.
9. Loose or damaged wiring.
10. Misaligned carburetor.
11. Engine valves not adjusted.
12. Blown fuse.
13. Stationary brake does not work.
1. Dirty air filter.
2. Defective spark plug.
3. Low or discharged battery.
4. Dirty fuel filter.
5. Old or dirty fuel.
6. Loose or damaged wiring.
7. Misaligned carburetor.
8. Engine valves not adjusted.
1. The brake pedal is not depressed.
2. The accessory clutch is.
3. Low or discharged battery.
4. Blown fuse.
5. Battery terminals corroded.
6. Loose or damaged wiring.
7. Faulty start key.
8. Defective starting system or solenoid.
9. The operator's presence key is defective. 9. Seek the professional services of the nearest
Solution
1. Fill the tank.
2. See "Starting the engine" in the Operation
section.
3. Wait several minutes before starting the
engine.
4. Replace the spark plug.
5. Recharge or replace the battery.
6. Replace/clean the air filter.
7. Replace the fuel filter.
8. Empty the tank and the carburetor, fill the
tank with fresh gasoline and replace the
fuel filter.
9. Check the entire wiring.
10. See "Adjusting the carburetor" in the
Repairs and Adjustments section.
11. Seek professional services of the closest
TRAPP Authorized Service Center.
12. Replace fuse.
13. See the brake pedal section, page 21.
1. Clean/replace the air filter.
2. Replace the spark plug.
3. Recharge or replace the battery.
4. Replace the fuel filter.
5. Empty the tank and fill it with new and
clean gasoline.
6. Check the entire wiring.
7. See "Adjusting the carburetor" in the
Repairs and Adjustments section.
8. Seek professional services of the closest
TRAPP Authorized Service Center.
1. Press the brake pedal.
2. Disengage the accessory clutch.
3. Recharge or replace the battery.
4. Replace the fuse.
5. Clean the battery terminals.
6. Check the entire wiring.
7. Check/replace the start key.
8. Check/replace the defective system or
solenoid.
TRAPP Authorized Service.
153