Troubleshooting - Pentair MYERS DS33P1 Manual Del Proprietário

troubleshooting

note: This pump has no serviceable parts inside case.
Opening case will ruin pump. If obstructions or blockages of
impeller cannot be cleaned out from the outside (for instance, by
washing out with a garden hose), replace pump.
Symptom poSSIble CaUSe(S)
Pump won't start
or run.
Pump starts and
stops too often.
Pump will not
shut off.
Pump operates but
delivers little or
no water.
limited Warranty
F.E. MYERS warrants to the original consumer purchaser ("Purchaser" or "You") of the products listed below, that they will be free from defects in material and workmanship for the
Warranty Period shown below.
Product
Jet pumps, small centrifugal pumps, submersible pumps and related accessories
Fibrewound Tanks
Steel Pressure Tanks
Sump/Sewage/Effluent Products
Our warranty will not apply to any product that, in our sole judgement, has been subject to negligence, misapplication, improper installation, or improper maintenance. Without
limiting the foregoing, operating a three phase motor with single phase power through a phase converter will void the warranty. Note also that three phase motors must be protected
by three-leg, ambient compensated, extra-quick trip overload relays of the recommended size or the warranty is void.
Your only remedy, and F.E. MYERS's only duty, is that F.E. MYERS repair or replace defective products (at F.E. MYERS's choice). You must pay all labor and shipping charges
associated with this warranty and must request warranty service through the installing dealer as soon as a problem is discovered. No request for service will be accepted if received
after the Warranty Period has expired. This warranty is not transferable.
F.E. MYERS SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL, INCIDENTAL, OR CONTINGENT DAMAGES WHATSOEVER.
THE FOREGOING LIMITED WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER EXPRESS AND IMPLIED WARRANTIES, INCLUDING BUT NOT LIMITED TO IMPLIED
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. THE FOREGOING LIMITED WARRANTIES SHALL NOT EXTEND BEYOND THE DURATION
PROVIDED HEREIN.
Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations on the duration of an implied warranty, so the above limitations or
exclusions may not apply to You. This warranty gives You specific legal rights and You may also have other rights which vary from state to state.
This Limited Warranty is effective June 1, 2011 and replaces all undated warranties and warranties dated before June 1, 2011.
1. Blown fuse.
2. Low line voltage.
3. Defective motor.
4. Defective float switch.
5. Impeller.
6. Float obstructed.
1. Backflow of water from piping.
2. Faulty float switch.
1. Defective float switch.
2. Restricted discharge
(obstacle in piping).
3. Float obstructed.
1. Low line voltage.
2. Something caught in impeller.
3. Worn or defective parts or
plugged impeller.
4. Airlock (check valve installed
without vent hole).
293 Wright Street, Delavan, WI 53115
Phone: 888-987-8677 • Fax: 800-426-9446 • www.femyers.com
In Canada: P. O. Box 9138, 269 Trillium Dr., Kitchener, Ontario N2G 4W5
Phone: 519-748-5470 • Fax: 888-606-5484
Hazardous voltage; can shock, burn, or kill.
Unplug pump before attempting to clean or work on pump.
CorreCtIve aCtIon
1. If blown, replace with fuse of proper size.
2. If voltage under recommended minimum, check
size of wiring from main switch on property. If OK,
contact power company or hydro authority.
3. Replace pump.
4. Replace switch.
5. If impeller won't turn, locate source of binding and
clean out with hose or remove.
6. Remove obstruction.
1. Install or replace check valve.
2. Replace switch.
1. Replace switch.
2. Remove pump and clean pump and piping.
3. Remove obstruction.
1. If voltage under recommended minimum, check size
of wiring from main switch on property. If OK,contact
power company or hydro authority.
2. Clean out impeller or replace pump.
3. Clean impeller if plugged; otherwise replace pump.
4. Drill a 1/16" - 1/8" dia. hole between pump
discharge & check valve.
Warranty Period
whichever occurs first:
12 months from date of original installation,
or 18 months from date of manufacture
5 years from date of original installation
5 years from date of original installation
12 months from date of original installation,
or 24 months from date of manufacture
f.e. myerS
4