Maintenance Schedule; Refueling - Honda iGX440 Manual Del Propietário

MAINTENANCE SCHEDULE

STANDARD TYPES
REGULAR SERVICE PERIOD (3)
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Engine oil Check level
Change
Air cleaner Check
Clean
Replace
Sediment cup Clean
Spark plug Check-adjust
Replace
Spark arrester Clean
Valve clearance Check-adjust
Timing belt Check
Combustion Clean
chamber
Fuel tank & Clean
filter
Fuel tube Check
LOW PROFILE TYPES
REGULAR SERVICE PERIOD (3)
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Engine oil Check level
Change
Air cleaner Check
Clean
Replace
Sediment cup Clean
Spark plug Check-adjust
Replace
Spark arrester Check-Clean
Valve clearance Check-adjust
Timing belt Check
Combustion Clean
chamber
Fuel tube Check
(1) Service more frequently when used in dusty areas.
(2) These items should be serviced by your Honda servicing
dealer, unless you have the proper tools and are mechanically
proficient. Refer to the Honda shop manual for service
procedures.
(3) For commercial use, log hours of operation to determine
proper maintenance intervals.
(4) Check that there is no crack and abnormal wear-out in the belt,
and replace if it is abnormal.
Failure to follow this maintenance schedule could result in non-
warrantable failures.
Each First Every 6 Every Every
Use Month Months Year 2 Years
or or or
20 Hrs 100 Hrs 300 Hrs 500 Hrs
(1)
(2)
After every 500 Hrs. (2) (4)
After every 500 Hrs. (2)
(2)
Every 2 years
(Replace if necessary) (2)
Each First Every 3 Every 6 Every
Use Month Months Months Year
or or or
20 Hrs 50 Hrs 100 Hrs 300 Hrs
(1)
After every 500 Hrs. (2) (4)
After every 500 Hrs. (2)
Every 2 years
(Replace if necessary) (2)
REFUELING (LOW PROFILE TYPES)
Follow the equipment manufacturers recommendation for

refueling.

Refer
REFUELING (STANDARD TYPES)
to
or Page
Recommended Fuel
Unleaded gasoline
U.S.
Except U.S.
8
9
9
This engine is certified to operate on unleaded gasoline with a
9
pump octane rating of 86 or higher (a research octane rating of 91
or higher).
10
Refuel in a well-ventilated area with the engine stopped. If the
11
engine has been running, allow it to cool first. Never refuel the
engine inside a building where gasoline fumes may reach flames
11
or sparks.
Shop
You may use regular unleaded gasoline containing no more than
manual
10% Ethanol (E10) or 5% Methanol by volume. In addition,
Shop
Methanol must contain cosolvents and corrosion inhibitors. Use of
manual
fuels with content of Ethanol or Methanol greater than shown
Shop
above may cause starting and/or performance problems. It may
manual
also damage metal, rubber, and plastic parts of the fuel system.
Shop
Engine damage or performance problems that result from using a
manual
fuel with percentages of Ethanol or Methanol greater than shown
Shop
above are not covered under warranty.
manual
Refer
Gasoline is highly flammable and explosive, and you
to
can be burned or seriously injured when refueling.
or Page
Stop engine and keep heat, sparks, and flame away.
Refuel only outdoors.
Wipe up spills immediately.
8
9
10
Fuel can damage paint and some types of plastic. Be careful not to
10
spill fuel when filling your fuel tank. Damage caused by spilled
fuel is not covered under the Distributor's Limited Warranty.
10
11
Never use stale or contaminated gasoline or oil/gasoline mixture.
Avoid getting dirt or water in the fuel tank.
11
1. With the engine stopped and on a level surface, remove the fuel
(2) Shop
filler cap and check the fuel level. Refill the tank if the fuel level
manual
is low.
Shop
manual
2. Add fuel to the bottom of the fuel level limit of the fuel tank. Do
Shop
not overfill. Wipe up spilled fuel before starting the engine.
manual
Shop
manual
FUEL TANK TOP
ENGLISH
Pump octane rating 86 or higher
Research octane rating 91 or higher
Pump octane rating 86 or higher
MAXIMUM
FUEL LEVEL
25 mm
(1 inch)
7