Cleaning Procedures - Pelton & Crane Validator Plus Instrucciones De Uso

B
A
C
MAINTENANCE

Cleaning Procedures

NOTE: Proper cleaning at regular intervals is essential, since
mineral deposits, debris or trash may cause the unit to
malfunction.
Draining Reservoir
With the door open, locate the quick drain connection (A) at the
lower right corner of the face plate. Press the drain tube connector
(B) provided with the unit into the connection on
the face plate. This opens the drain line and draining of the reservoir
will begin immediately.
Normal Chamber Cleaning
Drain the reservoir using quick connect drain tube. Mix Omni-Cleaner
with distilled quality water (water with 0-5 PPM dissolved
Plus ®
solids) water according to directions on bottle. Pour into reservoir.
Run one "Unwrapped" cycle (Note: It is not necessary to com-
plete drying cycle). Drain reservoir. With the drain tube in place,
pour one to two gallons of water into the reservoir until the drained
water is clear.
This will remove excess suds. Wipe inside of the chamber with soft
cloth.
! WARNING: Do Not sterilize instruments while cleaning
autoclave.
Pour half gallon distilled quality water (water with 0-5 PPM
dissolved solids) water into reservoir. Run one "Unwrapped"
cycle
(Note: It is not necessary to complete drying cycle). Wipe the
inside of the chamber, the boiler ring (C) and the door gasket. Fill
reservoir with distilled quality water (water with 0-5 PPM
dissolved solids) water. Autoclave is ready for use.
Cleaning Deposits and Discoloration on Stainless Steel
For deposits not removed by detergent solution, use a non-
chlorinated, non-metallic scouring pad such as Scotch-Brite
powder such as Bon-Ami
! CAUTION: Do not use ordinary steel wool or steel brushes
on stainless steel. Pads containing metal will damage
chamber and cause instruments to be stained with rust.
! CAUTION: Do not use chlorinated cleaners. Doing so will
cause corrosion.
Rub in direction of pattern or grain of the metal. Clean stainless steel
surfaces contaminated with discoloration with a 5% solution of warm
oxalic acid.
-28-
® .
or a
®