STOPPING THE MOWER (Fig. H1 – Fig. H6)
NOTICE: After more than 60 minutes without operating,
the mower will automatically shut off.
Limp-home mode
When battery charge becomes low, the mower will go
into Limp-Home mode:
◾
The mower automatically stop grass cutting;
◾
The beep indicator will continue to sound;
◾
The mower status indicator will flash red every
second, the first segment of the mower fuel-gauge
will flash red and both the low-power indicator and
the battery graphics on the fuel gauge will flash.
The operator should:
a) Push the PTO switch downward (Fig. H3) to
disengage the blades. The beep indicator will stop
sounding when the blade stops;
b) Stop working and go to the battery charging area as
soon as possible. The maximum distance the mower
can travel is 1000 m.
When the battery is nearly depleted, the icon of each
occupied battery compartment and low-power indicator
will blink every half a second. The mower will stop
working immediately. The operator should transport the
mower to the battery charging area for charging.
Manual pushing
If manual pushing is needed, be sure that the batteries
are disconnected from the mower and the parking-brake
pedal is release from the braking position.
DRIVING THE MOWER (Fig. I1 – Fig. I9)
To stop, decrease or increase speed, slowly change the
steering lever's distance from neutral.
DANGER: Stay at least two mowing widths away
from any ditches, drop-offs, or water. Front wheels can
rotate when the mower is stopped, even with the brake
applied, and cause the mower to go over the edge or
into the water and result in death or serious personal
injury.
WARNING: Be aware of what is behind the mower
before backing up. DO NOT mow in reverse unless
absolutely necessary. Always look down and behind
before and while backing to make sure no children,
bystanders, or pets enter the mowing area. Remember
that a careless fraction of a second is sufficient to inflict
death or serious injury.
WARNING: Do not operate this machine on public
roadways.
WARNING: If blockage happens or you strike a
foreign object, stop the motors and remove the batteries.
Remove grass clippings, leaves, dirt and any other
accumulated debris; thoroughly inspect the mower for
damage and repair the damage before restarting and
operating the mower.
MAINTENANCE
WARNING: Always wear eye protection with side
shields. Failure to do so could result in objects being
thrown into your eyes resulting in possible serious injury.
WARNING: Always protect your hands by wearing
heavy gloves or wrapping the cutting edges with rags
or other materials when performing any maintenance
on the mower blade. Always remove the safety key and
battery packs when servicing or transporting the mower.
Maintenance
Maintenance Procedure
Service Interval
◾
Check the safety-interlock
system.
◾
Visually check the tire whether it
is flat.
◾
Inspect the blades if it is worn,
crack or bent.
Before each use
◾
Inspect the entire product for
or daily
damaged, missing, or loose parts
such as side-discharge chute,
screws, nuts, bolts, caps, etc.,
ensuring that all guards are in
place and working properly.
◾
Check the brake operation.
◾
Clean the mower deck.
After each use
◾
Check the tire pressure.
Every 25 hours
◾
Check the grease condition
Every 50 hours
inside the cutting blade flange.
◾
Check the rear wheels, ensuring
that the all lug nuts are fastened
Every 100 hours
at the recommended torque.
◾
Check the front wheels, ensuring
Every 200 hours
that they turn freely.
ZERO TURN RIDE-ON MOWER — ZT5200E-L
EN
27
