Tabla de contenido
GB
1. Assembly of the front wheels
Press the button in the middle of the rim and hold it until you have pushed the wheel onto the axle
as far as it will go. If you now pull the wheel slightly, it must not come loose from the axle.
Repeat this on the other side. The wheel can be removed again by pressing in the middle of the
rim and pulling off the wheel.
2. Attach the Steering Column
Insert the straight end of steering column up through the hole bottom side. Insert the bent end of
steering column through the hole in the front axle linkage.
3+4. Mounting the rear-view mirrors
Open the door and place the rear-view mirrors (part 4) in the intended position. Fix the rear-view
mirrors with the corresponding screws (part 17) as shown in the pictures.
5+6. Mounting the steering wheel and gear stick
Connect the cable from the steering wheel to the cable from the body hole. Then plug the connec-
ted cables back into the body hole.
Place the steering wheel (part 3) on the steering column. Tighten the steering wheel with the stee-
ring wheel screw (part 15) and the steering wheel nut (part 19). Then bring the gearshift stick
(part 5) to the intended position and push it downwards to fix it.
7. Battery connection
Connect all connectors as shown. Only connect plug connections that fit into each other and take
care not to reverse polarity. Make sure that the red cable (plus) and the black cable (minus) are
connected to the respective connectors of the same colour.
8+9. Mounting the seat
After installing the power supply, place the seat (part 8) on the intended location and fix it with the
seat screw (part 16). Now place the backrest (part 9) on the designated spot and fix it with the
designated screws (part 16).
10+11. Mounting the windscreen and rear spoiler
Move the windshield (part 2) to the intended position. Push the spigots into the grooves until they
engage. Position the rear spoiler in the direction shown. Now press until the rear spoiler is fixed.
12. Opening the car door
Press the switch outside the vehicle door and then pull the door out to open it.
Explanation
6.
Front Wheel
7.
Driving Wheel
11.
Connection-rod
13.
Rear wheel axle
14.
Screw
18.
Lock nut
21.
Gearbox
Troubleshooting
1. The vehicle does not run
● The battery may low on power.
After each use, or once a month minimum, charge the battery. Do not
leave the battery on the charger for more than 15 hours.
● Thermal fuse has tripped.
The vehicle is equipped with a self-resetting fuse. When the
vehicle is overloaded or operated incorrectly; the self-resetting
fuse will be cut off for 5 - 20 seconds before becoming
operational again. The self-resetting fuse is under the seat
Cut off the power, follow these guidelines:
- DO NOT overload the vehicle, Maximum weight allowed: 30 kg
- DO NOT tow anything behind the vehicle.
- DO NOT drive up steep slopes.
- DO NOT drive into fixed objects, which may cause the wheels to spin, causing the motor
to overheat.
- DO NOT drive in very hot weather, components may overheat.
- DO NOT tamper with the electric system, Doing so may create a short circuit, causing the fuse
to trip.
● Battery connector or wires are loose.
Make Sure the battery connectors are firmly plugged in to each other.
● Battery is dead.
Have you properly maintained the battery according to the directions? Is the battery old?
Your battery may need to be replaced.
● Electric system is damaged.
Water may have corroded the system, or loose dirt, gravel or sand might have jammed the
switch.
● Motor is damaged.
The motor needs professional repair.
Charging Your Vehicle
• The power swich must be turned in OFF position when charging.
• The charging slot is located at the bottom of the seat and the overcurrent protection
under the seat.
• Plug the charger port into the input socket and plug the charger plug into a wall outlet.
• A red LED lights up on the charger. If the LED changes to green, the charging process is
finished.
• The charge time is between 8 and 12 hours. Do not charge the battery more than once
within 24 hours.
• When the vehicle begins to run slowly, recharge thebattery.
• Charger and battery heat up during the charging process.
• Charging should only be done by adults and not by children.
• If the car is overloaded, the overcurrent protection automatically disconnects the circuit.
• The engine is equipped with an active protection. In case of a voltage overload the engi
ne is switched off. In this case switch off the vehicle, wait for about 30 seconds and the fuse
should switch the electricity supply on.
Signal/
Signal/
Signal
Signal
Ladebuchse/
Ladebuchse/
Charging Socket
Charging Socket
Warning!
• Let the model cool off sufficiently after each use before putting it back into operation.
When using an additional batteries let it cool off for minimum 15 minutes until the
model is operated again. Overheating can damage the electronics or may result in fire.
• Always disconnect the model from the charger immediately after charging. Always
disconnect the charger from the power supply immediately after disconnecting the
model. Inserting the rechargeable model or charger after charging will result in damage
to the model, charger or the power supply (fire hazard).
2. The battery will not recharge
● Battery connector or adapter connector is loose.
Make sure the battery connector and adapter connector are firmly plugged together.
● Charger is not plugged in.
Make sure the charger is plugged into the wall outlet and the power flow to the outlet is on.
● Charger is not working.
Is the charger warm while charging? If not, the charger may.
3. The vehicle does not run very long.
● Battery may be undercharged.
You may not be charging the battery long enough. After each use, or once a month minimum,
charge the battery. Do not leave the battery on the charger for more than
15 hours.
● Battery is old.
The battery will eventually lose the ability to hold a charge. Depending on the amount of use,
and varying conditions, the battery should operate for one to three years. Replace the battery
with a new one.
4. Battery buzzes or gurgles when charging.
● This is normal and not a cause for concern. It may also be silent when charging, which is also
normal.
5. Charger feels warm when recharging battery.
● This is normal and not a cause for concern.
20
Ladekabel/
Ladekabel/
Charging plug
Charging plug
7
Tabla de contenido
