GB
1.
Assembly of the front wheels
Place the body with the underside facing up.
Slide a Ø10 washer (A) onto the front axle. Attach a wheel (10) and a washer (A) onto the
axle. Fix the whole thing with a clip (B). Finally, put a cover (11) on the wheel. Repeat this on
the other side.
2.
Assembly of the rear wheels
Install the drive motor (9) into the rear axle, connect the motor wire plug with the plug in at the
motor clamp port, and insert the motor into the clamp slot. Put the driving wheel (10) on the
rear axle and slide a washer onto the axle. Fix the whole thing with a clip (B). Finally, put a
cover (11) on the wheel. Repeat this on the other side.
3.
Assembly of the pedals
Install the pedal (12) into the car body and fixed it with 4 screws (C).
4.
Assembly of the rear support
Place the iron sheet (14) as shown and fixed it with screw (C).
5.
Assembly of the steering wheel, the spare wheel dummy and the rear window
Steering wheel
Connect the cable from the steering wheel to the cable of the dashboard. Install the steering
wheel (3) in the intended position and secure it with the safety screw (D) and nut (E)
Spare wheel dummy
Install the spare wheel dummy (6) on the back of car body and fixed it with 2 screws (C).
Rear window
Fixed the rear window (7) on the back of car body and fixed it with 2 screws (C).
6.
Mounting the windshield, the car windows and the wing mirror
Insert the windshield (1) in the slot on the car body and fixed it with 2 schrews (C):
Install the car windows (4) to the destignated position and fasten it.
Install wing mirror (5) to the designated position, and fasten it.
7.
Battery connection
Connect all connectors as shown. Only connect plug connections that fit into each other
(A = battery, B = gear) and take care not to reverse polarity. Make sure that the red cable
(plus) and the black cable (minus) are connected to the respective connectors of the same
colour.
8.
Mounting the seat
Put the upper cover seat into the corresponding buckle groove for internal fixation. Slip the
lower cover cushion (2) flat into the upper cover cushion chuck. Fixed with 2 screws (C).
d
1
4
5
6
7
Troubleshooting
1. The vehicle does not run
● The battery may low on power.
After each use, or once a month minimum, charge the battery. Do not leave the battery on the
charger for more than 7 hours.
● Thermal fuse has tripped.
The vehicle is equipped with a self-resetting fuse. When the vehicle is overloaded or operated
incorrectly; the self-resetting fuse will be cut off for 5 - 20 seconds before becoming
operational again. The self-resetting fuse is under the seat
Cut off the power, follow these guidelines:
- DO NOT overload the vehicle, Maximum weight allowed: 30 kg
- DO NOT tow anything behind the vehicle.
- DO NOT drive up steep slopes.
- DO NOT drive into fixed objects, which may cause the wheels to spin, causing the motor
to overheat.
- DO NOT drive in very hot weather, components may overheat.
- DO NOT tamper with the electric system, Doing so may create a short circuit, causing the
fuse to trip.
● Battery connector or wires are loose.
Make Sure the battery connectors are firmly plugged in to each other.
● Battery is dead.
Have you properly maintained the battery according to the directions? Is the battery old?
Your battery may need to be replaced.
● Electric system is damaged.
Water may have corroded the system, or loose dirt, gravel or sand might have jammed the
switch.
● Motor is damaged.
The motor needs professional repair.
8 8
2
3
8
9
10 11
12
9.
Charging Your Vehicle
• The power swich must be turned in OFF position when charging.
• Insert the charger (13) into the socket - the LED lights up green. Connect the charger to
the charging socket on the dashboard.
• The LED on your charger lights up red as long as the battery is being charged. If the LED
lights green again, the battery is fully charged.
• The charge time is between 6 and 7 hours.
• Do not charge the battery more than once within 24 hours.
• Charger and battery heat up during the charging process.
Warning!
• Let the model cool off sufficiently after each use before putting it back into
operation. When using an additional batteries let it cool off for minimum 15 minutes
until the model is operated again. Overheating can damage the electronics or may
result in fire.
• Always disconnect the model from the charger immediately after charging. Always
disconnect the charger from the power supply immediately after disconnecting the
model. Inserting the rechargeable model or charger after charging will result in
damage tothe model, charger or the power supply (fire hazard).
10. Functions
a Foot pedal
To move the car, press the pedal down.
To brake or slow down, release pressure from the pedal.
b Shift lever
Changes the direction of the car, Forward - Stop - Backward
IMPORTANT!
Always stop vehicle when changing the speed or direction to avoid damage the
gears and motor.
c. Horn
d. Control board
Control board
1
USB
After inserting a USB stick
2
Voltage display
3
Charging socket
4
Light button
With the switch to turn on the lights ON or OFF
5
Previous Music/Volume -
Press these buttons briefly to select the previous song to play.
Press these buttons for 2 seconds and the volume will decrease
6
Music button
7
Next Music/Volume +
Press these buttons briefly to select the next song to play.
Press these buttons for 2 seconds and the volume will increase.
8
Power button
Long press it 3 seconds, turn the vehicle on and off.
Short press it for 1 second, stop the music from the car.
9
High speed button
Change the speed of the car more quickly
10
Low speed button
Change the speed of the car more slowly
11
Bluetooth speaker
Press this button, connect ehe mobile phone and Bluetooth in the car, then the car can play
music from your mobile phone.
12
FM Radio
2. The battery will not recharge
● Battery connector or adapter connector is loose.
Make sure the battery connector and adapter connector are firmly plugged together.
● Charger is not plugged in.
Make sure the charger is plugged into the wall outlet and the power flow to the outlet is on.
● Charger is not working.
Is the charger warm while charging? If not, the charger may.
3. The vehicle does not run very long.
● Battery may be undercharged.
You may not be charging the battery long enough. After each use, or once a month minimum,
charge the battery. Do not leave the battery on the charger for more than 7 hours.
● Battery is old.
The battery will eventually lose the ability to hold a charge. Depending on the amount of use,
and varying conditions, the battery should operate for one to three years. Replace the battery
with a new one.
4. Battery buzzes or gurgles when charging.
● This is normal and not a cause for concern. It may also be silent when charging, which is also
normal.
5. Charger feels warm when recharging battery.
● This is normal and not a cause for concern.
