Automatic Suction Shut-Off; Two Year Home Use Warranty; Troubleshooting - Shop-Vac 12S Serie Manual Del Usuario

AUTOMATIC SUCTION SHUT-Off

The vacuum is equipped with an automatic suction shut-off that operates when picking up
liquids. As the level of the liquid rises in the tank, an internal float rises until it seats itself
against a seal at the intake of the motor, shutting off suction. When this happens, the motor will
develop a higher than normal pitch noise and the suction is drastically reduced. If this occurs,
turn unit off immediately. failure to turn unit off after float rises and shuts off suction will result
in extensive damage to the motor. To continue use, empty the liquid waste from the tank as
outlined in the previous paragraph.
NOTE: If ACCIdenTALLy TIPPed OVeR, The VACuuM COuLd LOSe SuCTIOn. If ThIS OCCuRS,
PLACe VAC In uPRIGhT POSITIOn And TuRn SWITCh Off. ThIS WILL ALLOW The fLOAT TO
ReTuRn TO ITS nORMAL POSITIOn, And yOu WILL Be ABLe TO COnTInue OPeRATIOn.
LUBRICATION
no lubrication is necessary as the motor is equipped with lifetime lubricated bearings.
Before storing your vacuum cleaner the tank should be
emptied and cleaned. The power cord can be wrapped
around the cord wraps provided on the tool holder (not
standard with all models) installed on rear of unit
(figure 27). If your unit does not come with a tool
holder, the cord can be wound around the tank cover
(figure 28). Accessories may be stored in the tool holder (not standard on all
models) so they can be readily available. The vacuum should be stored indoors.

TROUBLESHOOTING

Trouble Possible Cause
Suction weakens or Clogged filter
cleaner runs hot
Air leak
Obstruction in hose
or nozzle
Misting in the Saturated filter
exhaust air
WARNING
SHOULD BECOME DETACHED OR BROkEN, EXPOSING THE MOTOR OR ANy
OTHER ELECTRICAL COMPONENTS, OPERATION SHOULD BE DISCONTINUED
IMMEDIATELy TO AVOID PERSONAL INjURy OR fURTHER DAMAGE TO THE
VACUUM. REPAIRS SHOULD BE MADE BEfORE REUSING THE VACUUM.

TWO yEAR HOME USE WARRANTy

your Shop-Vac® vacuum cleaner is warranted for normal household use, in accordance with
the user Manual, against original defects in material and workmanship for a period of two years
from date of purchase. Should this product be used for commercial or rental use, a 90 day lim-
ited warranty will apply. Shop-Vac Corporation warrants placing this vacuum cleaner in correct
operating condition, by repair or parts replacement, during the warranty period, without charge.
This warranty does not cover accessories. use of non-recommended filters and/or accessories
may void the manufacturer's warranty. Shop-Vac® assumes no responsibility for damage or
faulty performance caused by misuse, careless handling, and where repairs or modifications
have been made. do not attempt to service your vacuum beyond that described in the user
Manual. Proof of purchase date is required. The warranty gives you specific legal rights, and you
may have other rights which vary from state to state or province to province. This warranty is
void outside of the united States and Canada.
Customers in the united States: for product service contact Shop-Vac Corporation, Customer
Service, at (570) 326-3557 or go to www.shopvac.com/support. Visit www.shopvac.com for
your vacuum's parts list schematic.
Customers in Canada: for product service return the complete unit, (transportation prepaid), to
®
the Authorized Shop-Vac Service Center nearest you. Visit www.shopvac.ca for a complete list of
Authorized Service Centers in your area.
Customers in Mexico: for product service see paperwork that came with your unit.
STORAGE
27
Remedy
Brush dirt from filter. If condition continues,
change filter.
Check all fittings for tight fit (nozzles, hose, etc.)
Check that tank cover is sealed properly.
Check nozzle, hose, etc. for obstructions, and
remove if present.
Replace saturated filter with a dry filter.
– If ANy Of THE MOTOR HOUSING PARTS
28