Honeywell Fendall Porta Stream III Manual De Instalación Y Funcionamiento

Honeywell 32-000310-0000 Porta Stream III Eyewash Station
Fendall Porta Stream
15-Minute Heated Emergency Eyewash Station
16-Gallon (61 Liters) Model #32-000310 Installation and Operation Manual
Unpack and Inspect
The Fendall Porta Stream III is delivered in one (1) box. Upon
receipt, check the shipping box for any damage. The following
items are contained in the box (please check the last page for
other items that may be included for your specific model):
1. Fendall Porta Stream III Station
2. Pull Strap
3. Metal Hanging Bracket
4. Insulated Jacket
5. Installation and Operation Manual
•The unit must be level for proper operation. (See "Choose a Location," page 1.)
!
WARNING:
•The Fendall Porta Stream III may weigh over 150 lbs. (70 kg) when filled with solution. Assistance may
•Do not add any product or material to the solution of Sperian
the Fendall Porta Stream III," page 2.)
• Employees must be instructed in the use of emergency eyewash stations. (See "Operation," page 3.)
•This emergency eyewash unit is intended for the emergency use of victims of eye contamination until
medical treatment is obtained. In all cases, the victim should seek medical attention immediately after
flushing. (See "Operation," page 3.)
•An individual or department must be assigned the task of checking all self-contained eyewash units on a
weekly basis. (See "Inspection and Maintenance," page 4.)
•All eyewash devices containing Sperian
and refilled per solution manufacturer's recommendations. Units containing just water need to be cleaned
and refilled at least once a week. (See "Inspection and Maintenance," page 4.)
•Use of a fluid beyond the expiration date may result in serious personal injury. (See "Inspection and
Maintenance," page 4.)
Failure to follow and comply with all instructions and cautions stated in this manual may result in serious personal injury,
serious illness, blindness or death.
Choose a Location
1. The unit shall be positioned with the nozzle(s) not less than 83.8 cm (33 in.) and no greater than 114.3 cm (45 in.) from the floor
and 15.3 cm (6 in.) minimum from the wall or nearest obstruction.
2. Eye wash units shall be in accessible locations that require no more than 10 seconds to reach. The eye wash shall be located
on the same level as the hazard and the path of travel shall be free of obstructions that may inhibit the immediate use of the
equipment. For a strong acid or a strong caustic, the eye wash should be immediately adjacent to the hazard.
3. Each eye wash location shall be identified with a highly visible sign positioned so the sign shall be visible within the area served
by the eye wash. The area around the eye wash shall be well lighted.
The Fendall Porta Stream III Emergency Eyewash Station must be installed in an easily accessible location in the immediate area
of hazard to the employee, according to ANSI Standard Z358.1-2004 requirements. The Fendall Porta Stream III may be placed
on any level surface of required height, such as a table or bench (allow for proper drainage and disposal of the flushing
solution). The Fendall Porta Stream III may also be mounted on a wall or post using the metal hanging bracket. The unit must be
level for proper operation. (See "Warning" on page 1.)
netzerotools.com netzerotools.com
III
®
be required when installing the unit on the hanging bracket. (See "Choose A Location," page 1.)
The ANSI Standard Z358.1-2004 requires that:
netzerotools.com
Insulated Jacket
Installation and
Operation
Manual
Pull Strap
Saline Concentrate and water. (See "Fill
®
® Saline Solution or Sperian
Fendall Porta
Stream III Station
Nozzle Assembly
Metal
Hanging
Bracket
® Water Additive should be cleaned