Before Each Use - 3M Ladder Climb Instrucciones De Uso

bracket (end anchorage) and used with the 3M
The back-up cable is constructed with ¼ inch 7x19 galvanized Aircraft cable with a 1⁄16 inch
vinyl coating, and is 13⅜ inches long.
The energy absorber and back-up cable are swaged to one end of the cable (thimble and two
swages), and the other end is unfi nished for system length adjustment with two 3M
M400-3 and one 3M TM
TM
3M B B
OTTOM RACKET
The 3M Bottom Bracket M400-2 of the 3M Ladder Climb Cable Vertical Lifeline is constructed
of hot dipped galvanized 2 inch square tube steel. The 18 inch long 3M Bottom Bracket M400-2
comes with a ⅜ x 6 inch eye bolt to connect the unfi nished end of the cable.
TM
3M C G
ABLE UIDES
The 3M Cable Guides M400-5 are a neoprene rubber guide with galvanized steel brackets and
hardware. The 3M Cable Guides M400-5 are to be placed at varying lengths to help reduce
harmonics and chatter in the cable. The 3M Cable Guides M400-5 are required at staggered
intervals starting at 25 feet.
TM
3M R R
OUND UNG
Rung Clamps are 2¾ inches wide with ⅜ inch galvanized steel bolts with two fl at washers and
two ⅜ inch nuts. 3M Round Rung Clamps M400-6 are for round rungs up to 1¼ inches and 3M
Square Rung Clamps M400-7 are for square rungs up to 2 inches.
TM
3M E T
XTENDED
The 3M Extended Top Bracket M400-10 of the 3M
constructed of hot dipped galvanized 2 inch square tube steel. The 7 foot long 3M Extended Top
Bracket M400-10 extends 54 inches above the top rung, allowing users to exit the ladder before
disconnecting from the system.
TM
3M C F
ABLE ALL
The 3M Cable Fall Arrester 128 used on the 3M Ladder Climb Cable Vertical Lifeline is self
trailing and constructed of stainless steel and brass, with a 0.78 inch connector for the carabiner.
H
ARDWARE
Carabiners used in the 3M Ladder Climb Cable Vertical Lifeline, marked with the ANSI Z359.1-
07, ANSI Z359.12-09 or CSA Z259.12-11 standard, are self-locking with a minimal tensile break
strength of 5,000 pounds (22.2 kN) and 3,600 pounds (16 kN) gate rating.
INSTALLATION
B E U
EFORE ACH SE
Users of personal fall arrest systems must have a rescue plan in place, if the user cannot rescue
themselves, as well as the means to carry out the rescue.
The user must read and understand these User Instructions, as well as the User Instructions for
every component/subsystem of the personal fall arrest system.
Misuse or failure to follow warnings and instructions may result in serious personal injury or death.
Thimble M400-8.
M400-2
M400-5
C M400-6
LAMPS
B M400-10
OP RACKET
A 128
RRESTER
TM Cable Fall Arrester 128 at a fall factor of two.
TM
3M S R
OR QUARE
TM
Ladder Climb Cable Vertical Lifeline is
6
TM
Fist Grips
C M400-7
UNG LAMPS