Graymills CLEAN-O-MATIC COM304 Instrucciones De Operacion Y Mantenimiento página 7

Air Motor (GAM) Characteristics
There is no pilot light or switch. The air connection is on the side of the tank with the valve. Minimum
60PSI air supply required with motor set at 1725RPM to have full pump performance.
Liquid Capacities
The liquid capacity of your Clean-O-Matic is as indicated below:
Weight Limitations
The maximum weights which can be placed on the tank bottom and work shelves of your Clean-O-
Matic are indicated below:
The work area should be well ventilated.
Provide adequate lighting in the work area to allow observation of the cleaning process and the floor
area around the machine. Be sure to allow adequate room to bring work to and from the machine.
Provide sufficient clearance around the machine for fluid changeovers and servicing.
Site Preparation
Before installing, careful consideration should be given to the place of operation. Place unit on a
smooth, level surface. To the extent possible avoid installing machine in areas subject to high forklift
traffic. Reasonable precautions shall be taken to avoid damaging the legs and tank walls.
Installation Procedure
The Clean-O-Matic is very easily put into operation. After removing it from its shipping carton, unpack
any trays and accessory components from inside the tank. Assemble the handle to the cover, and
install any parts shelfs (this will ensure freeboard compliance). Check to be sure drain plug is tightened,
fill with the desired amount of an appropriate cleaning fluid (see Liquid Capacities, above) and insert the
3-prong plug into the proper receptacle (see electrical specifications above). If using an air motor,
attach airline hose to valve on side of unit and the unit is ready for use.
Before operating your Clean-O-Matic, read the following descriptions of its features and benefits to
maximize efficiency and longevity from your unit.
Automatic Safety Cover
Open the automatic Safety Cover (FIGURE 1 (A)) on your Clean-O-Matic and you will notice that it lifts
simply and easily with one hand. There is nothing to connect or disconnect to open or close the cover.
795-93851
Model Maximum
304, 504
40 gals
604 54.5 gals
804 81.5 gals
904, 924 109.5 gals
Model
304, 504, 804
904, 924
INSTALLATION AND OPERATION
7 of 49
Minimum
20 gals
28 gals
49 gals
39.5 gals
Bottom Shelves
500 lbs. 150 lbs.
750 lbs. 200 lbs.
12/15/21