Ingersoll Rand ARO 650556 Manual Del Usuario

OPERATOR'S MANUAL
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
INCLUDE MANUALS: 66301 X LOWER PUMP END (PN 97999 647), 650684 X PUMP (97999 656), 65142X X
FILTER (97999 6), P292X1 XXX PIGGYBACK (PN 100400 8) & GENERAL INFORMATION S 636 (97999 636)
AIRLESS SPRAY PUMP SYSTEM - CART MOUNTED
SISTEMA DE BOMBA PULVERIZADORA SIN AIRE - MONTADO EN CARRETILLA
SYSTÈME DE POMPE DE PULVÉRISATION SANS AIR - MONTÉ SUR CHARIOT
6" STAINLESS STEEL, TWO BALL PUMP, 45:1 RATIO
SERVICE KITS
• Use only genuine ARO
replacement parts to assure compatible
R
pressure rating and longest service life.
• 61355 for repair of Air Motor section.
Service Note: The Air Motor Service / Parts Manual is not shipped
with the pump but it is included with each Service Kit. If this Service
/ Parts Information is needed, request the Air Motor Operator's
Manual from ARO. (Manual 6564X X, PN 97999 174).
• 637306 P43 for repair of Lower Pump section.
PUMP SYSTEM DATA
Model . . . . . . . . . . . . . . . . . . .
Pump System Type . . . . . . . . .
Pump Model . . . . . . . . . . . . . .
Ratio . . . . . . . . . . . . . . . . . . . .
Air Inlet . . . . . . . . . . . . . . . .
Air Exhaust . . . . . . . . . . . . .
Material Inlet . . . . . . . . . . . . .
Dimensional Data . . . . . . . .
Air Motor . . . . . . . . . . . . . . . . .
Motor Repair Kit . . . . . . . . . .
Lower Pump End . . . . . . . . . . .
Lower Pump Repair Kit . . . .
Weight (less carton) . . . . . . .
PERFORMANCE
Air Inlet Pressure Range . . . . .
Fluid Pressure Range . . . . . . .
Max. Rec'd Cycles / Minute . . .
3
Displacement In Per Cycle . . .
Volume / Cycle . . . . . . . . . . . .
Cycles Per Gallon . . . . . . . . . .
Flow @ 60 Cycles / Minute . . .
Noise Level @ 60 Psi 40 Cpm 84.8 db(A)
* The pump sound pressure level has been updated to an Equivalent Continuous Sound Level
(L ) to meet the intent of ANSI S1. 13 1971, CAGI PNEUROP S5.1 using four microphone
Aeq
locations.
OPERATING INSTRUCTIONS
DO NOT EXCEED MAXIMUM OPERATING PRESSURE
WARNING
OF 5400 P.S.I. (372 BAR) AT 120 P.S.I. (8.3 BAR) AIR INLET PRESSURE.
REFER TO THE PUMP MANUAL FOR ADDITIONAL OP
WARNING
ERATING AND SAFETY PRECAUTIONS AND OTHER IMPORTANT IN
FORMATION.
INGERSOLL-RAND COMPANY
P.O. BOX 151 ONE ARO CENTER
D
&
D
(419) 636-4242 FAX (419) 633-1674
650556
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
650556
Cart Mounted Portable,
Air Operated, Two Ball S'Steel
650684 P43
45:1
1/2" 14 N.P.T.F. 1 (female)
Muffler included
Suction Tube
See page 3.
65665 B
61355
66301 P43
637306 P43
111 Lbs (50 Kgs)
30 120 p.s.i. (2 8.3 bar)
1350 5400 p.s.i. (93 372 bar)
60
7.5
4.1 oz. (121 ml)
30.9
1.9 g.p.m. (7.2 lpm)
BRYAN, OHIO 43506 0151
D
E
2000 D PRINTED IN U.S.A.
RELEASED / LIBERADO / DECHARGE: 5-1-96
REVISED / REVISADO / REVISE:
Inlet Air Regulator and Material Outlet ManIfold are not shown, see Fig. 2
El regulador de entrada de aire y el distribuidor de salida de materiales no se muestran, ver la figura 2.
Régulateur d'entrée d'air et tubulure de sortie de matériel non montrés, voir Fig. 2
IMPORTANT This is one of the six documents which support
the system. Replacement copies of these forms are available
upon request.
- 66301 X LOWER PUMP END OPERATOR'S MANUAL
(97999 647)
= 650556 PUMP SYSTEM MANUAL (97999 670)
- 650684 X PUMP MODEL OPERATOR'S MANUAL (97999 656)
- P292X1 XXX PIGGYBACK OPERATOR'S MANUAL (100400 8)
- 65142X X MATERIAL FILTER (97999 6)
- GENERAL INFORMATION MANUAL S 636 (97999 636)
650556
11-15-00
(REV. D)
FIGURE 1