Maintenance; Maintenance Plan - entrematic Ditec Sector Manual De Instalación, Manutención, Uso

8. MAINTENANCE TO BE CARRIEd OUT EVERY 6 MONTHS
Regular inspections should be made according to national regulations and product documentation by a Entrematic Group AB
trained and qualified technician. The number of service occasions should be in accordance with national requirements and
product documentation.
Installation / Fitting
• Tighten the fitting screws of the uprights with the crosspiece
• Check the anchoring of the door to the door frame
Motor
• Check the fixing of the motor to the relevant support
• Check the tensioning of the transmission chain
• Check the limit switches functioning and the good alignment with the cams.
• Check the brake disc wearing. If necessary replace the disc
• Check the properly manual release lever brake functioning (when applicable)
• Check the wear and tear of the counterweight belt. Replace the belt if necessary.
Main Shaft
• Check the good bearing supports fixing
• Lubricate the support of the bearings by suitable grease inlet
Safety devices
• Check the good safety bar functioning
• Check the good conditions of the safety bar rubber profile
• Check the adjusting and the eventual wearing of the steel cable of the electromechanical safety edge
• Check the wearing of the mobile cable
• Check the wearing of the side plastic safety edge shoes
• Check the correct operation of the safety photocells

8.1 Maintenance Plan

The table below shows the recommended interval - in months - when to replace parts during preventive maintenance.
Part
Limit switch group
Limit switch
Brake disc
Brake disc guide
Safety edge shoe
Safety edge cabling
Belt counterweight
(1) Dirty or dusty environment, operating temperature near to 0°C or over 35°C, wind pressure within 20% of maximum limit.
0DT827 2014-06-13
<10
Part number
Low Traffic
Months
6K10GF
36
5M
48
21572
36
21571
36
27925
24
27796
36
RCP40550
36
- 40 -
Cycles / hour
<30 >30
Medium Traffic High Traffic
Months Months
24 12
36 24
24 12
24 12
24 12
24 12
24 12
Abusive
Environment
(1)
12
24
12
12
12
12
12