WARRIOR LDG12S Manual De Instrucciones página 7

WPE DIESEL GENERATORS
EVERY 100 HOURS OR 3 MONTHS
— Chain oil
— Change oil filter
— Change fuel filter
— Clean Air Filter
— Check/Adjust valve clearance*
EVERY 2 YEARS
— Replace fuel line*
* Special tools or skills are required - please do not attempt
yourself - consult Technical Support on 44(0)1942 715 407.
Changing engine oil (Every 100Hrs)
Refill with the recommended oil 10W30 Non or part
synthetic.
1. Open left door, use the fork to release the drain plug
(don't take out screw), put the oil guide groove under
the drain plug, let its outlet connect with oil container,
then completely remove the oil drain plug.
2. Begin to release out the oil and when the oil sump is
empty, if necessary, use the diesel to clean the inside
of the cylinder block.
3. Replace the drain plug.
4. Move the plastic rounded lid on the top of generator,
unscrew the cylinder head oil cap, fill the oil until
reach the oil gauge max limited in the end screw back
the cylinder head stud.
Cleaning the air filter (Every 100 hours)
Move the upper plate and back cover of the generator,
you will see the air cleaner. release the clip, unload the
lower half part of the air cleaner, and take out the filter
element in the middle; wash the filter element with diesel
fuel and put it back in the air cleaner after it is dry.
Checking and replenishing battery fluid and charging
and battery (Monthly)
This diesel engine uses a 12v battery. The battery fluid will
be lost through continuous charging and discharging.
Before starting , check for physical damage to the
battery and also the electrolyte level, and replenish
with distilled water up to the upper mark if necessary.
When actual damage is discovered , replace the battery
immediately. Batteries are covered by 12 months
warranty from the original date of purchase.
STORAGE
If your generator should be stored in long time, the
following preparation should be made.
1. Operate the diesel engine about 10 minutes with NO
load and stop it.
2. Wait approx. 10 mins when the engine is still warm,
drain engine oil out, then refill new 10W30 engine oil.
7
STORAGE
EN