Troubleshooting; Technical Specifi Cations - Advance VacRide 3400 Instrucciones De Uso

GENERAL MACHINE TROUBLESHOOTING
Problem
Poor vacuuming performance
Side broom does not operate
Machine does not run
No FWD/REV wheel drive
Filter bag full indicator is lit when
fi lter bag is not full
TECHNICAL SPECIFICATIONS (as installed and tested on the unit)
Model
Model No.
Voltage, Batteries
Battery Capacity
Protection Grade
Sound Pressure level – LpA
(IEC 60335-2-72, ISO 11201)
Sound Pressure level - KpA
(IEC 60335-2-72, ISO 11201) Uncertainty
Gross Weight
Maximum Wheel Floor Loading (center front)
Maximum Wheel Floor Loading (right rear)
Maximum Wheel Floor Loading (left rear)
Vibrations at the Hand Controls
(ISO 5349-1)
Vibrations at the Hand Controls
(ISO 5349-1) Uncertainty
Vibrations at the Seat (EN 1032/ISO 2631-1)
Vibrations at the Seat (EN 1032/ISO 2631-1)
Uncertainty
Gradeability Transport
Gradeability Cleaning
-C = Onboard Charger
Possible Cause
Wand Control Lever set to Wand instead
of brushes
Brushes are worn or have taken a set
Moving machine too fast
Side broom is in the raised storage
position
Tripped 5 Amp circuit breaker
Battery connector disconnected
Operator seat safety switch
Main system controller
Tripped 10 Amp circuit breaker
Drive system speed controller
Tripped 70 Amp circuit breaker
Emergency stop switch tripped
Blocked HEPA fi lters
Blocked wand tool or hose
VacRide 3400
56602000
V 24V
Ah 305/415
Do not spray
67.0
dB(A)
64.0 (quiet mode)
dB(A) 3.0
lbs / kg 1,026/465.4
psi / kg/cm 158 / 11.1
2
psi / kg/cm 115 / 8.1
2
psi / kg/cm 85 / 5.9
2
m/s .25
2
m/s .05
2
m/s .01
2
m/s .002
2
16% (9°)
9% (5°)
Remedy
Rotate the wand control lever to brushes
Replace brushes
Slow down
Lower the side broom into the operating
position
Check for and remove the cause of the
side broom motor overload (binding etc.).
Reset the circuit breaker.
Reconnect battery connectors
Check for open circuit and replace
Check error fault codes
(see service manual)
Check for electrical short circuit & reset
Check error fault codes
(see service manual)
Check for drive motor overload
Reset the Emergency Stop Switch
Clean fi lters or replace if necessary
Clear the hose
VacRide 3400-C
56602001
24V
305/415
Do not spray
67.0
64.0 (quiet mode)
3.0
1,026/465.4
158 / 11.1
115 / 8.1
85 / 5.9
.25
.05
.01
.002
16% (9°)
9% (5°)
FORM NO. 56041798 - VacRide - A-17
ENGLISH / A-17