EN
PROBLEM
There are grass or debris remaining
on the ground after mowing.
Short run time of the tractor with
included batteries.
The tractor is not tracking straight.
The parking-brake pedal cannot be
released from the parking-brake
position or is slow to spring back.
The tractor cannot be charged via
charging port with the tractor status
indicator shining solid red.
The charging time via the tractor
charging port is too long.
The batteries cannot be fully
charged via the tractor charging
port.
The tractor cannot be started after
cleaning.
The deck gets clogged fast.
The tractor easily loses traction
when climbing up on the slope.
When the tractor is stopped on a
slope with the parking-brake pedal
engaged, the tractor can roll down
the slope.
28
ELECTRIC LAWN TRACTOR — TR4200E
CAUSE
◾
The deck is set to cut too much grass
at once when the grass is tall.
◾
The grass is wet.
◾
The driving speed is high.
◾
The blade speed is low.
◾
Lawn terrain, grass conditions,
cutting-height setting, driving speed,
blade speed, etc. will greatly affect the
running time.
◾
The tire pressures for the left and right
wheels are different.
◾
The travel path of the parking-brake
pedal is clogged with debris.
◾
The plug of the charger is not inserted
correctly into the charging port on the
tractor.
◾
There is no power in the wall outlets.
◾
Charger malfunction.
◾
The charger port on the tractor is
faulty.
◾
Using EGO Adapter ACA1000 for
charging requires long time.
◾
Firmware bug of the tractor or the
battery pack or the charger failure.
◾
Improper cleaning, such as water
getting on the electric components,
LCD screen etc.
◾
The deck was not properly cleaned
after previous use.
◾
The tires of the rear wheels are worn.
◾
Mowing on a steep slope.
◾
The brake components are excessively
worn due to improper operation of the
tractor.
SOLUTION
◾
Begin with a high cutting height and reduce it until the
desired mowing result is attained. Grass over 152 mm
tall should be mowed twice, at successively lower cutting
heights.
◾
Do not mow when the grass is wet. Wait until the grass
dries.
◾
Slow down the driving speed.
◾
Increase the blade speed gradually.
◾
Raise the deck cutting height and slow down the blade
speed to reduce the cutting load.
◾
Check and adjust the air pressure in both front rear
wheel tires, according to the recommendation in section
"SPECIFICATIONS" in this manual.
◾
Check and remove the debris.
◾
Reconnect the charger plug to see whether the tractor
can be charged normally.
◾
No action is needed. Wait until the power recovers.
◾
Please contact EGO customer service center and have the
charger inspected and/or repaired if needed by a qualified
service technician.
◾
Please contact EGO customer service center for repair.
◾
Use EGO charger CHV1600E for charging the electric lawn
tractor directly.
◾
Reset the charger by unplugging the charger and waiting
for several minutes. Then reconnect the plug to the
power supply. If this does not solve the problem, call EGO
Customer Service Center.
1. Follow the instructions in section "GENERAL
MAINTENANCE"to clean the tractor correctly.
2. If the tractor caught in rain accidentally, leave it to dry or
use compressed air to dry it.
◾
Clean the tractor deck after each use, following the
section "Using wash port to clean the deck".
◾
Seek local service to replace the wheel tires.
◾
The tractor should not be used to mow slopes steeper
than required degrees.
◾
Contact EGO customer service center for repair.
