TerraKing 45-0582 Manual Del Propietário página 4

7
Install part ST43509 here (Optional)
P
Install part ST43509 here (Optional)
ENGLISH
SAFETY
1. Read this owners manual and the vehicle owners manual before
using this sprayer.
2. Never allow children to operate this sprayer.
3. Do not allow anyone to ride on or sit on this sprayer.
4. Keep the area clear of all persons, especially small children.
5. Read the chemical label before handling or mixing chemicals.
6. Wear eye and hand protection and protective clothing when
handling and applying lawn chemicals.
7. Always release pressure in the system before filling, cleaning, or
servicing the sprayer.
8. Liquid spray material is recommended. Sprayer does not agitate
wettable powders.
9. Do not spray on windy days.
10. Stop sprayer when tank is empty.
11. Be aware of your vehicle's capabilities. The 45 gallon sprayer
weighs 45 lb (20 kg) empty and 420 lb (191 kg) full.
12. Attaching this sprayer may affect your vehicle's braking and
stability.
13. STAY OFF STEEP SLOPES. Refer to the vehicle owner's manual
concerning safe operation on slopes.
14. Operate at reduced speed on rough terrain, along ditches, and on
hillsides to prevent loss of control.
15. Stopping distance increases with speed and weight. Travel slowly
and allow extra time and distance to stop.
ASSEMBLY
The meanings of symbols used in the illustrations are as follows:
Do not overtighten.
OPERATION
CAUTION: Connect to a 12 V battery only.
O
Tighten now.
8
PUMP PRESSURE SWITCH
The pump pressure switch turns off the pump when it reaches
its maximum pressure setting. Very low flow demand may cause
the switch to rapidly cycle the pump on and off. Rapid on and off
cycling must be limited to no more than 6 times per minute. Cycling
could cause the motor to heat beyond the recommended maximum
temperature and reduce the operational life of the pump and pressure
switch.
SPRAYER CONTROLS
Boom ON-OFF valve shuts off the flow to the boom nozzles.
ADJUSTABLE SPRAY WAND NOZZLE
Twisting the nozzle will adjust the spray pattern from a cone shaped
mist to a solid stream.
SPRAYER RECIRCULATION
1. The sprayer is equipped with a recirculation valve to aid in material
agitation and pressure control.
2. This valve is in the "open" position when the valve handle is in line
with the hose, "closed" when perpendicular to the hose.
3. Adjusting the recirculation valve between the open/closed positions
will affect the pressure coming through the spray wand.
4. Closed position is full pressure through spray wand.
5. It may be helpful to adjust the pressure when spraying with the
spray wand to avoid damage to plants from excess pressure.
BEFORE STARTING
1. Connect the wire harness from the switch to the pump.
2. Check for leaks using plain water. Fix leaking fittings with thread
tape.
CAUTION: Wear eye and hand protection and protective
clothing when handling and working with lawn chemicals.
4
Recirculation Valve
Boom Valve