Idiomas disponibles
Idiomas disponibles
5.6 DRAINS: Press firmly on the Chloraloy using drain body as a cutting template to cut the opening.
CAUTION: When cutting bolt holes, do not cut beyond outside perimeter of clamping area. Snug bolts evenly and then tighten firmly to make a
watertight seal. Apply a bead of NobleSealant 150 under the sheet over the clamping ring drain body.
5.7 PENETRATIONS: If it becomes necessary to penetrate the membrane below the waterline or in any other critical area, use a piece of Chloraloy 2"
larger (all sides) than damaged area and seal the patch over the damaged Chloraloy with NobleSealant 150 or NobleWeld 100.
5.8 SEAMING AND JOINING PROCEDURES: When the area to be waterproofed is wider than the width of a sheet, sheets may be seamed (joined)
using NobleSealant 150 or NobleWeld 100. Both methods provide permanent, waterproof seams.
CAUTION: Bonding area must be dry, clean, and free of dust, dirt, oil, and grease.
5.8.a NOBLESEALANT 150 (see instructions on tube):
a. Lay out sheets to overlap approximately 2" and mark.
b. Apply a 3/16" bead of NobleSealant 150 3/4" from edge.
c. Overlap first sheet and flatten beads with hand roller, trowel, or putty knife.
5.9 TESTING: Test in accordance with local plumbing codes. Inspect for leakage. If leaking is detected, first re-tighten clamping ring, then inspect ring
to be certain it mates with the drain body and is not warped. If defective, replace. It may be possible to seal by welding a second layer of Chloraloy
in area of drain body and/or sealing with NobleSealant 150. Repeat testing until no leaks can be detected.
TIP: To protect liner from damage, water may be left in pan.
6. INSTALL MORTAR BED
Install mortar bed per TCNA/ANSI recommendations.
7. WARRANTY
Chloraloy is guaranteed for the lifetime of the original tile installation by Noble Company against failure caused by rotting, cracking, and microorganism
deterioration when properly installed in concealed construction waterproofing and applications for which its use is recommended by Noble Company.
This warranty is limited to replacement of defective material and freight charges to destination only. There are no other expressed or implied warranties,
and this warranty is in lieu of any other warranty, including, but not limited to, implied warranties of merchantability and fitness for purpose. Noble
Company is not responsible for consequential damages. The remedy of the purchaser set forth herein is exclusive.
NOTE: Chloraloy MUST BE INSTALLED IN STRICT COMPLIANCE WITH THESE INSTRUCTIONS, APPLICABLE ANSI STANDARDS, TCNA
RECOMMENDATIONS, AND BUILDING CODES.
These suggestions and data are based on information Noble Company believes to be reliable. Users should verify by tests that Chloraloy, as well as
these installation methods, are suitable with the products being used in their application. Since specific use, materials, and handling are not controlled
by Noble Company, this warranty is limited to the replacement of defective Noble Company products. Noble Company disclaims any responsibility for (a)
warranties of merchantability and fitness for purpose; (b) verbal recommendations of its representatives; and (c) consequential damages.
8. FIGURES/DRAWINGS
FIGURE 1. TYPICAL SHOWER
Color Logo and Logo w/Slogan
Simple Solutions... Proven Performance
Black Logo and Logo w/Slogan
White and Color Logo and Logo w/Slogan
NOT TO SCALE
FOLLOW TCNA RECOMMENDATIONS
1. INSTALL SUITABLE TILE BACKER BOARD
IN ACCORDANCE WITH MANUFACTURER'S
INSTRUCTIONS
2. REINFORCEMENT REQUIRED FOR MORTAR
BED > 65 SQ. FT.
P.O. Box 350 · Grand Haven, MI 49417-0350 · 800-878-5788 · Fax: 231-799-8850 · www.noblecompany.com
® Registered Trademark of Noble Company ™ Trademark of Noble Company, Grand Haven, MI. © 2018 Noble Company
File #CL122018-08 | 12/18 | Supersedes CL052016-05
Simple Solutions... Proven Performance
Solid White Logo and Logo w/Slogan
White and Transparent Logo and Logo w
FIGURE 2. CORNERS
FOLDED CORNER
FOLDED CORNER
TUCKED CORNER
FOLDED CORNER
FOLDED CORNER
TUCKED CORNER
Simple Solutions... Proven Performance
PREFORMED DAM
PREFORMED DAM
PREFORMED
OUTSIDE CORNER
PREFORMED DAM
CORNER
PREFORMED DAM
CORNER
PREFORMED
OUTSIDE CORNER
CORNER
CORNER
TUCKED CORNER
IN
TUCKED CORNER
IN
PREFORMED
OUTSIDE CORNER
PREFORMED
OUTSIDE CORNER
