Operation - Thetford SANICON TURBO 500 S Manual Del Propietário

Overview
Congratulations on your purchase of the SANICON® 500S - the
cleanest, most sanitary, and convenient way to empty your RV
holding tank!
Read and understand the warnings listed in this docu-
AVISO AVIS
! ! ! ! NOTICE ATTENTION ATENCIÓN CAUTION DANGER
ment before you operate or service this system. If you do
ATTENTION ATTENTION ATTENTION
not obey these warnings there is a risk of property loss,
injury, or electrocution. Do not make any changes to this
unit as this could result in property damage, injury, or
electrocution.
Thetford Corporation accepts no responsibility or liability for
damage to equipment, injury, or death that may result from the
system's improper installation, service, or operation.
Thetford Corporation recommends that plumbing and electrical
work be performed by a licensed tradesperson. Local permit and
code compliance is required.
Cautions and Warnings
Read and understand the warnings and cautions listed in this
document before you operate, or service this unit.
Wear appropriate personal protective equipment when
AVISO AVIS
! ! ! ! NOTICE ATTENTION ATENCIÓN DANGER CAUTION
using the SANICON® system.
ATTENTION ATTENTION ATTENTION
Do not make any changes to this unit, as this could result
NOTICE AVISO AVIS
! CAUTION
in property damage or injury.
■
Flush only organic human waste and toilet tissue.
Do not fl ush non-dissolving articles such as feminine
hygiene products, paper towels, or moist towelettes,
as this will damage the macerator and will void your
warranty.
■ To avoid pump failure, if you are using an accessory
garden hose on the end of the nozzle, make sure
that the inner diameter of the hose is .75" (1.9 cm) or
greater.
Questions?
If you have any questions or need assistance, please contact
Customer Service at 1-800-543-1219, available Monday through
Friday 8 a.m. to 6 p.m., Eastern Standard Time.
Inspect pump connection to the RV annually. Make sure
NOTICE
there are no cracks in the rubber coupling and the mount-
ing hardware is secure. Replace when necessary.
To extend the life of the discharge hose
NOTICE
sharp bends and stress at hose cuffs and support the
hose within 2"- 5" of cuff
®
SANICON Turbo - Model 500

Operation

,
(K2) avoid
when in use.
(K2.1)
Pump Performance
Performance varies with hose size and length:
Hose
& Length
SANICON ® hose 1.5" x 21'
SANICON ® hose 1.5" x 21'
SANICON ® hose 1.5" x 21' w/
100' 3/4" garden hose
®
SANICON hose 1.5" x 21' w/
100' 3/4" garden hose
SANICON ® hose 1.5" x 21' w/ 50'
3/4" garden hose
Thermal cut-off will occur after 20 minutes. Refer to
i
"Thermal Cut-Off Switch" discussion.
Attach To Dump Station
Refer to Fig. 1 and Fig. 5.
1. Open hose storage compartment (
and nozzle with caps (
coach.
Remove cap (
NOTICE
2. Unscrew large nozzle cap (
3. Attach universal nozzle (
Empty Black Water Tank
Refer to Fig. 1 and Fig. 5.
1. ENSURE universal nozzle (
to dump station! Refer to "Attach to Dump Station"
procedure.
TIP For Cleaner Storage: Emptying the black water tank
NOTICE
fi rst, allows gray water to cleanse the system.
2. Open black water tank gate valve (
3. Use ( K3 ) to turn pump on.
4. Do not leave unit unattended.
5. Use ( K3 ) to turn pump off.
TIP: The hose expands as fl uid moves to dump station
NOTICE
and contracts when tank is empty.
6. Close black water tank gate valve (
7
Height Flow
Rate
(gal/
min)
9' 11.1
0 18.7
9' 0.7
0 3.7
0 6.2
); pull out hose
5D
); do not disconnect from
K2
) for full hose extension.
K2.4
).
K2.4
K2.2 ) to dump station.
) is securely attached
K2.2
).
4B
4B ).
97572 Rev. B (07/10/2017)
Minutes
to Empty
100 Gal-
lons
9
5
143
i
27
i
16