Trouble Shooting Chart - Stenhoj MASCOT 1.25 Instrucciones De Operacion Y Mantenimiento

T60649
Note:
Due to the fine and precise tolerances of spindles and nuts, these must be carefully maintained. They must be kept
absolutely clean and should always be well lubricated (cp. lubrication instructions below). If these instructions are
ignored, there is a risk that the spindles will be damaged.
Due to the construction of the safety system they do not require maintenance, however, we recommend that the movable
parts on the top of the posts are greased once every 6 months.
Lubrication:
Lubricate the lift every 6 months as follows:
WHERE
Chain
Roller pipes/guides
Spindles/nuts
Top casing
Suspension for arms
Arm locks
WARRANTY:
This lift is guaranteed for one year, covering faults due to manufacturing or material defects, provided that the enclosed
guarantee certificate, filled in and signed, is returned immediately upon installation of the lift and provided that the
installation, operation and maintenance instructions are observed.
IMPORTANT ! Product liability accepted only if solely original Stenhø j spare parts have been used.
SYMPTOM
Lift will neither
rise nor lower
Lift unusually
noisy
Revision:
MAINTENANCE
Remove cover plate
Remove steel bands from front
edges of posts
Remove top cover

TROUBLE SHOOTING CHART

CAUSE
Main nut broken
Snapped safety wire
Electricity cut
Overload
Chain too slack
Defective limit switch
Obstruction under arms or
carriages
Fault in the electrical
system
Expansion bolts for base
frame loose
HOW
The lifting carriage is supported solely by the
safety nut. Do not use the lift before the damage
has been repaired. Call authorized fitter.
Replace wire
Check fuses. Call authorized electrician
Remove load
Tighten chain (adjust the post in the oblong
holes). Torque: 100 Nm (10 Kpm)
Replace limit switch
Raise carriage carefully e.g. by means of a jack
and remove obstruction
Call authorized electrician
Tighten expansion bolts
WHAT
Lithium grease
Lithium grease
Molybdenum grease (apply with
brush)
Lithium grease
Lithium grease
Lubricating oil
REMEDY
8