High Altitude Operation - Kohler Courage XT Serie El Manual Del Propietario

Starting
Carbon Monoxide can cause
severe nausea, fainting or death.
Avoid inhaling exhaust fumes.
Engine exhaust gases contain poisonous
carbon monoxide. Carbon monoxide is
odorless, colorless, and can cause death if
inhaled.
Rotating Parts can cause severe
injury.
Stay away while engine is in
operation.
Keep hands, feet, hair, and clothing away
from all moving parts to prevent injury. Never
operate engine with covers, shrouds, or
guards removed.
NOTE: Over priming may make it difficult to
start engine. It is usually not necessary
to prime a warm engine.
NOTE: Choke position for starting may vary
depending upon temperature and other
factors. Once engine is running and
warm, turn choke to OFF position.
NOTE: Extend starter cord periodically to
check its condition. If cord is frayed
have it replaced immediately by a
Kohler authorized dealer.
1. Turn fuel shut-off valve to ON position
(if equipped).
2. Turn engine on/off switch to ON position
(if equipped).
3. Start engine as follows:
a. Primer Bulb Models: Place finger or
thumb on center of primer bulb. Push
primer 3 times.
b. Manual Choke Models:
Cold engine: Place throttle control to
FAST position. Pull choke control into
CHOKE/ON position.
Warm engine: place throttle control to
RUN/FAST position.
c. Smart-Choke
automatically adjusts choke on start-up.
4
WARNING
WARNING
or
or
Models: this feature
™
4. Retractable Start: Slowly pull starter handle
until just past compression-STOP! Return
starter handle; firmly pull straight out to avoid
excessive rope wear from starter rope guide.
Electric Start: Key switch (refer to operating
instructions of equipment that this engine
powers).
5. Gradually return choke control to OFF
position after engine starts and warms up.
Engine/equipment may be operated during
warm up period, but it may be necessary to
leave choke partially on until engine warms
up.
Cold Weather Starting Hints
1. Use proper oil for temperature expected.
2. Disengage all possible external loads.
3. Use fresh winter grade fuel. Winter grade
fuel has higher volatility to improve starting.
Stopping
1. If possible, remove load by disengaging all
PTO driven attachments.
2. If equipped, move throttle control to slow or
idle position; stop engine.
3. If equipped, close fuel shut-off valve.
Angle of Operation
Refer to operating instructions of equipment
this engine powers. Do not operate this engine
exceeding maximum angle of operation; see
specification table. Engine damage could result
from insufficient lubrication.
Engine Speed
NOTE: Do not tamper with governor setting to

High Altitude Operation

This engine may require a high altitude
carburetor kit to ensure correct engine
operation at altitudes above 4000 ft.
(1219 meters). To obtain high altitude kit
information or to find a Kohler authorized dealer
visit KohlerEngines.com or call 1-800-544-2444
(U.S. and Canada).
This engine should be operated in its original
configuration below 4000 ft. (1219 meters) as
damage may occur if high altitude carburetor kit
is installed and operated below 4000 ft. (1219
meters).
KohlerEngines.com
increase maximum engine speed.
Overspeed is hazardous and will void
warranty.
14 590 10 Rev. A