Care And Maintenance - Perel WEH200 Manual Del Usuario

7.

Care and Maintenance

WARNING – Always ensure the appliance is disconnected to the mains supply before
starting any servicing work.
Cleaning

Keep all safety devices, air vents and the motor housing free of dirt and dust as far
as possible.

We recommend that you clean the appliance immediately each time you have
finished using it.

Wipe the appliance with a clean cloth or blow it with compressed air at low
pressure.

Clean the appliance regularly with a moist cloth and some soft soap. Do not use
cleaning agents or solvents; these could attack the plastic parts of the equipment.
Ensure that no water can seep into the appliance.
Servicing
In the following: One cycle means one raising and lowering movement of a load.
Periodic inspection means an inspection after 100 cycles.

Test periodically that the limit switches on the cable hoist are in correct working
order. Conduct this test as follows: When the cable has reached the maximum
height, the lever on the automatic stopping mechanism will be actuated. The motor
must then stop. (Test without a load). When the steel cable has been unwound as
far as possible, the lever for the maximum cable length will be actuated. The motor
must then stop.

Inspect the mains cable and the control cable periodically.

The steel cable and return roller must be greased every 200 cycles.

A check must be made every 30 cycles to find whether the entire steel cable is in
good condition. If it is damaged, it must be replaced by a steel cable of the type
specified in the technical data.

Check every 1000 cycles whether the screws for the fastening bars and return roller
are properly tightened.

Check every 1000 cycles whether the hooks (8/16) and return roller are in good
condition.

Check before using the cable hoist whether the emergency stop switch and push
buttons are in perfect working order.

Check the braking system every 1000 cycles. If the motor makes any unusual
noises or cannot raise the rated load, it is possible that the braking system requires
an overhaul:
Storage
Store the appliance and its accessories out of children's reach in a dark and dry place at
above freezing temperature. The ideal storage temperature is between 5 and 30 °C.
Store the appliance in its original packaging.
V. 04 – 12/06/2019
Replace damaged or worn parts and keep the service documentation relating
o
to this in a safe place.
Please contact an authorized service centre for any unscheduled maintenance
o
work.
WEH200/WEH300
8 ©Velleman nv