Operation; Starting; Cold Start; Warm Start - Zipper ZI-RAM80V Manual De Instrucciones

13

OPERATION

Secure the working area properly before you start to compact.

Never attempt to put the machine into service without having read the security, setup and

operation instruction in this manual and having performed all necessary checks and tasks de-
scribed in the chapter before.
The correct level of humidity is decisive for good compacting results. Humidity is a kind of

lubrication helping to compress particles more together.
Compacting an underground without any humidity is not possible. Too high levels of humidity
make compacting ineffective as well and might cause the machine to stall.
Do not use the tamping rammer at hard undergrounds, frozen underground or rocky under-

ground.

13.1 Starting

13.1.1 Cold start

Figures see start of this manual
 Main switch (D) ON
 Open fuel cock (C) entirely
 Bring throttle lever (A) into middle speed position (middle position)
 Close the choker (B)
 Recoil start: Grip the handle (E) oft he recoil starter, pull it back slightly until you feel re-
sistance, let it roll back, pull it out briskly in one pull entirely.
 If the engine does not start after the 3
 When the engine started, open the choke, adjust throttle in order that the engine runs idle.
Let the engine run in idle for at least some minutes.
 To start to compact bring the throttle lever into max. speed position!

13.1.2 Warm start

 Main switch (D) ON
 Open fuel cock (C) entirely
 Bring throttle lever (A) into middle speed position (middle position)
 Check whether Choke (B) is open, no choke at warm start!
 Start the motor with recoil starter
13.2

Turn the machine off

Bring the machine into idle run by bringing the throttle lever into min. speed. Let the motor
run in idle speed for about 2 minutes. Bring the main switch into OFF position.
Close the fuel cock (C) entirely.
ZIPPER MASCHINEN GmbH www.zipper-maschinen.at
Vibrationsstampfer / Vibrating tamper / Pison vibrador / Pilonneuse
rd attempt, open the choke slightly.
ZI-RAM80Vite 28
OPERATION
Seite 28